FLYLINE SOLAR CHARGE PROCESSING UNIT
Flyline renewable energy charging control is a devise to control and utilize DC solar power. The main function of a charge controller or regulator is to protect your battery from overcharge and block a reverse current. Charging Controllers helps to get full panel output power. It regulates the voltage and current coming from the solar panels going to the battery. If a non-self-regulating solar array is connected to lead acid batteries with no overcharge protection (i.e. without charging controllers) the batteries life would be compromised.Simple controllers contain a transistor that shunt the PV charging circuit, terminating the charge at a pre-set high voltage and, once a pre-set reconnect is reached, opens the shunt, allowing charging to resume. The existing inverters and UPS in any capacity using by normal electricity power can also be use by solar power by adopting a proportionate capacity of flyline solar charge controller and photovoltaic panels manually which helps to reduce electricity bill. Murickens manufactured and market three types of charging controllers MOSFET, IGBT and MPPT charging controller with international quality.
MURICKEN GROUP'S PRODUCTS INSTALLATION VIDEO
MOSFET Pulse Width Modulation Solar Charging Controllers (PWM) Common Features
► The main advantage of Flyline Solar Charger is high efficient " Zero Drop" (we get 100 % efficiency).
► Comparing to MPPT, there is no heat conversion efficiency lose in this special model.
► German Technology assures the quality of product.
► ISO 9001- 2015 certified Flyline Solar Charger.
► It is commonly used products.
► This charging controllers are used for smaller and medium power controlling units.
► The technical features are same with IGBT.
► The control system controls the whole system taking care of battery over charging cut off, deep discharging cut off, protections in battery reverse, PV reverse, Overload and Short circuit.
► Our product connection diagram printed on it.
► Micro controller based.
► LED, bar glass or LCD - display-battery voltage, load on/off, battery condition charging on/of . in 12/24 Vf.
► Up to 80 amp auto detection for 12v/24v (automatic sensing)
FLYLINE Pulse Width Modulation Solar Charging Controllers (PWM) Common Features
:► The main advantage of Flyline Solar Charger is high efficient " Zero Drop" (we get 100 % efficiency).
►Comparing to MPPT, there is no heat conversion efficiency lose in this special model.
►German Technology assures the quality of product.
► ISO 9001- 2015 certified Flyline Solar Charger.
► It is commonly used products.
► This charging controllers are used for smaller and medium power controlling units.
► The technical features are same with IGBT.
► The control system controls the whole system taking care of battery over charging cut off, deep discharging cut off, protections in battery reverse, PV reverse, Overload and Short circuit. ► Our product connection diagram printed on it
►Micro controller based.
►LED, bar glass or LCD - display-battery voltage, load on/off, battery condition charging on/off.
►Up to 70 amp auto detection for 12v/24v (automatic sensing).
| FLYLINE PWM/MOSFET SOLAR CHARGER CONTROLLER TECHNICAL FEATURES | |
Switching |
Zero drop back to back PWM MOSFET base |
|---|---|
Nominal battery voltage |
12 V to 48 V DC |
Maximum out put amp |
4AMP- 100 AMP |
Stand by consumption |
less than 1w |
Charging REG |
2 stage |
Battery tem combination |
5MV@40DIG |
Product Display |
LED, bar graph or LCD |
Max. panel input voltage |
16V@12V |
Battery input |
8 to15 Volt (for 12 V).19 to 30 Volt ( for 24 V) |
Panel input |
10 to30 Volt (for 24 V).21 to 60 Volt ( for 24 V) |
Battery input |
32 to 60 Volt ( for 48 V) |
Panel input |
40 to 120 Volt ( for 48 V) |
Mobile charging |
USB & DC SOCKET in small capacities |
DC LOAD |
UN REGULATED |
Efficiency |
100 % |
IGBT SOLAR CHARGING CONTROLLERS COMMON FEATURES
► It is used for high voltage regulations.
►German Technology assures the quality of Flyline Solar Charger.
► ISO 9001- 2015 certified
► Zero Drop model (we get 100 % efficiency).
►It is commonly used products.
► IGBT charging controllers are used for medium and higher power controlling units.
► The technical features of MOSFET and IGBT are same.
► The control system controls the whole system taking care of battery over charging cut off, deep discharging cut off, protections in battery reverse, PV reverse, overload and short circuit.
►Micro controller base.
►LCD display panel voltage , battery voltage, out current, solar in use, direct mains, saved unit
FLYLINE PWM/IGBT SOLAR CHARGER CONTROLLER TECHNICAL FEATURES
Switching |
Zero drop back to back PWM MOSFET base |
|---|---|
Nominal battery voltage |
12 V to 48 V DC |
Maximum out put amp |
4AMP- 80 AMP |
Stand by consumption |
less than 1w |
Charging REG |
2 stage |
Battery tem combination |
5MV@40DIG |
Product Display |
LED, bar graph or LCD |
Max. panel input voltage |
16V@12V |
Battery input |
8 to15 Volt (for 12 V).19 to 30 Volt ( for 24 V) |
Panel input |
10 to30 Volt (for 24 V).21 to50 Volt ( for 36 V) |
Battery input |
32 to 60 Volt ( for 48 V) |
Panel input |
40 to 120 Volt ( for 48 V) |
Mobile charging |
USB & DC SOCKET in small capacities |
DC LOAD |
UN REGULATED |
Efficiency |
100 % |
MPPT ( maximum power point Tracker) charging controller
► In the art of solar MPPT (Maximum Power Point Tracker) determines the ideal operating point via processor –controller algorithm. This significantly of incident light and temperature.
► The control system controls the whole system taking care of battery over charging cut off, deep discharging cut off, protections in battery reverse, PV reverse, overload and short circuit.
►MPPT Solar Charger have a power to increases the photovoltaic array power yield.
►It is most suitable for smaller power applications. If we use for higher application heat conversion lose is very high.
►Micro controller base.
►LCD display-panel voltage , battery voltage, out current, solar in use, direct mains, saved unit,
FLYLINE MPPT SOLAR CHARGER CONTROLLER TECHNICAL FEATURES
| FLYLINE MPPT SOLAR CHARGER CONTROLLER TECHNICAL FEATURES | |
Nominal battery voltage |
12v to 192 v dc |
|---|---|
Maximum out put amp |
40 to 80amp |
Maximum solar array |
2000 w @40 amp, 4000w@ 80 amp in 48 v |
PV open CKT voltage |
120v @48 v design |
Stand by consumption |
less than 2w |
Charging REG |
5 stage |
Battery tem combination |
5MV@40DIG |
Switching method |
Buck boost DC to DC converter |
Maximum Efficiency |
98% |
Flyline Solar Charge Controller Images :- Click Here
Flyline Solar Charge Controller Details :- Click Here
Product Short Informative Videos:- Click here
Product Detailed Informative Videos:- Click here
Useful technical informative videos:- Click here
Green Energy Promotion Videos By MG Group:-Click Now
Watts of some electronic products we use :-Click Here
Flyline Solar power plant installation video of MG Marketing System:- Click Here
Murickens GOVT clients list :- Click Here
Murickes Brouchure:-Click Here
For quick response & order-call ( 91) 09400464444, 09447366779, 08281848484